So lets face it: your stock horn SUCKS. It's wimpy, it's not loud, and every time you hear a train pass by you wish you could have the same horn and have a blast with it.. well, good news! IT'S HERE! All in one complete package that is sure to get you going!
The Conductor's Special 540 train horn kit delivers the performance you need. It features the insanely loud, American-made, Shocker XL Train Horns. These horns are hand-tuned in the USA to the government mandated train signal chord. Simply put, they sound completely authentic. With the 4 horns being individually mounted they are the most versatile when it comes to mounting. The horns can be scattered out and mounted in just about any configuration needed. Coupled with these impressive horns is an even more impressive air system. This air system was designed from the ground up to work amazingly with train horns and it does just that. The 5-gallon tank can recharge from 110 to 150 PSI in just 1 minute and 45 seconds! This is because we matched Viair’s highest performing compressor in its class, the 400C. This pump is powerful and comes with Viair’s impressive reliability and warranty. With this being a fast fill compressor it doesn't have a very long duty cycle. Meaning the compressor can fill the tank fast but cannot be running for long amounts of time. The system is mainly meant for just the train horns but can be used for any pnuematic use in an emergency situation. With the 110/150 PSI pressure switch with a built-in relay included in the kit, it will kick the compressor on when the system drops below 110 PSI. Then when the system reaches 150 PSI it will turn the compressor off. Making this a completely self-contained unit. The relay acts as a shield for the pressure switch by taking most of the amp draw. Wiring the pressure switch and relay correctly will also allow the system to only run while the vehicle is on as well. Meaning the only thing you ever have to do is make sure to drain the tank of moisture on a regular basis!
Ideal For Mobile Air Applications
If you've ever planned on adding air suspension, now you're half way there. What about air tools? With 5 gallons of air you've got more than enough to run air tools, air jacks, air ride, or even inflate tires.
Also featured in this kit is a remote mountable intake assembly, or "Snorkel Kit", for the air compressor. This allows the compressor to be mounted just about anywhere where it would normally suck up dirt, debris, moisture, or any other contaminant. You can place the air intake filter safely up to 6 feet away with the included air line!
- Shocker S4 Train Horns
- 1/2 in NPT Electric Solenoid Valve
- DOT Rated 5 Gallon Air Tank
- Viair 400C Compressor
- Viair 110/150 PSI Pressure Switch
- Remote Mountable Intake Filter
- Air Filter Cartridges
- 10 ft of 5/16 in D.O.T. Approved Airline
- 17 ft of 1/2 in D.O.T. Approved Airline
- 6 ft of 3/8 in Airline (For Intake)
- HornBlasters 200 PSI Air Gauge
- 18 ft of 10 Gauge Power Wire
- 18 ft of 18 Gauge Power Wire
- Wiring Kit w/ Fuse Holder
- Brass NPT Fittings Kit Including Safety Valve and Blowoff
- Mounting Hardware
- Detailed Instructions
- Earplugs
Please note finishes for the compressor may vary. Silver and chrome are available. If you have a preference please call before making your purchase.
WARNING: HORNS PRODUCE EXTREME LOUDNESS
Use this product in a safe and responsible manner, at a distance of at aleast 100 feet from others.
Proper Hearing protection must be worn when using this airhorn. Hearing loss or permanent damage may result from unsafe use.
Never operate this product in a closed environment or close to pedestrians or others.
It is the consumer's responsibility to comply with local noise ordinances and D.O.T. sound level laws.
[ITEMPRICE]